Product ID:BARRETT'S POLYURETHANE CLEAR PLASTIC COATING-GLOSS
MSDS Date:02/18/1992
FSC:8010
NIIN:00D004303
Status Code:A
MSDS Number: CJGPL

BARRETT VARNISH COMPANY

1532 SOUTH 50TH COURT
CICERO, IL 60650

Emergency Phone: 312-242-2462

Info Phone: (312) 242-2462

Preparer: RCC

Cage: 1JP53

PAXTON/PATTERSON (800-262-1909)

UNKNOW ROANOKE, VA 24033 US

Telephone: (800-336-5998)

Cage: 00EN5

STODDARD SOLVENT/PETROLEUM SOLVENT

CAS: 8052-41-3

RTECS: WJ8925000

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9495

NAPHTHA, HEAVY ALKYLATE/PETROLEUM HYDROCARBON MIXTURE

CAS: 64741-65-7

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

ZIRCONIUM/ZIRCONIUM COMPOUNDS

CAS: 7440-67-7

RTECS: ZH7070000

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3/10 STEL;9495

MEDIUM OIL ALKYD

OIL MODIFIED POLYURETHANE

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: SPRAY MISTS MAY CAUSE
SEVERE LUNG IRRITATION OR LUNG DAMAGE. BREATHING OF HIGH VAPOR
CONCENTRATIONS MAY PRODUCE NARCOSIS.
Explanation of Carcinogenicity:CONTAINS NO KNOWN OR SUSPECTED
CARCINOGENS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO
SOLVENTS CAN CAUSE A HEIGHTENED REACTION TO EXPOSURE TO THIS
PRODUCT. CENTRAL NERVOUS SYSTEM DEPRESSION.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
NOT IN DUCE VOMITING. IF CONSCIOUS, RINSE MOUTH WITH WATER. SEEK
IMMEDIATE MEDICAL ATTENTION. IF SPONTANEOUS VOMITING OCCURS,
MONITOR FOR BREATHING DIFFICULTY.

Flash Point Method:SCC
Flash Point:=37.8C, 100.F
Lower Limits:0.7%
Upper Limits:7.0%
Extinguishing Media: FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:USE APPROVED SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE CLOTHING
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, SPARKS, ELECTRICAL EQUIPMENT, APPLIANCES, PILOT LIGHTS,
FLAMES AND OTHER SOURCES OF IGNITION. VAPORS MAY MIGRATE TO AN
IGNITION SOURCE AND CAUSE A FL ASH FIRE.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN SPILL. RECOVER FREE LIQUID.
PICK UP SPILL WITH NON-FLAMMABLE ABSORBENT SUCH AS SAND,
VERMICULITE/NON-SPARKING PUMP. PR EVENT LIQUID FROM ENTERING SEWERS
OR WATERWAYS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN A COOL, WELL VENTILATED AREA
AWAY FROM SOURCES OF IGNITION & INCOMPATIBLE MATERIALS. KEEP OUT OF
REACH OF CHILDREN. DO NOT BREATH SPRAY MIST.
Other Precautions:AVOID BREATHING VAPORS. DO NOT GET IN EYES, ON SKIN
OR ON CLOTHING. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
DRINKING. REMOVE CONTAMINATED CLOTHING PROMPTLY. LAUNDER BEFORE
REUSE.

Respiratory Protection:USE NIOSH/OSHA-APPROVED AIR SUPPLIED RESPIRATOR
IF TLV'S WILL BE EXCEEDED DESPITE ENVIRONMENTAL CONTROLS.
Ventilation:SUFFICIENT VENTILATION, IN VOLUME AND PATTERN, SHOULD BE
PROVIDED TO KEEP AIR CONTAMINATION BELOW CURRENT APPLICABLE OSHA
PERMISSIBLE LIMIT/ACGIH'S TLV LIMIT.
Protective Gloves:CHEMICAL RESISTANT, PLASTIC OR RUBBER
Eye Protection:CHEMICAL GOGGLES WITH SIDE SHIELDS OR FACE SHIELD
Other Protective Equipment:AS REQUIRED TO AVOID WETTING CLOTHING. USE
PROTECTIVE CREAMS WHERE SKIN CONTACT IS LIKELY. REMOVE AND WASH
CONTAMINATED CLOTHING BEFORE REUSE. EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING. SMOKE IN
DESIGNATED AREAS ONLY. ALL EQUIPMENT SHOULD COMPLY WITH SECTIONS
1910.132-135 OSHA STANDARDS.
Supplemental Safety and Health

HCC:F4
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:277F - 406F
Vapor Density:>AIR
VOC Pounds/Gallon:524
VOC Grams/Liter:4.37
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID - SOLVENT ODOR
Percent Volatiles by Volume:67.6%

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:SPARKS, OPEN FLAMES, AND EXCESSIVE HEAT
Hazardous Decomposition Products:CARBON DIOXIDE AND/OR CARBON
MONOXIDE(COMBUSTION BYPRODUCTS).

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.

State Regulatory Information:CALIFORNIA PROPOSITION 65: CALIFORNIA
PROPOSITION 65 DOES NOT APPLY TO THIS MATERIAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.